Wanted: Coolant temperature sending unit connector

Post in this forum for cars and/or parts wanted.

Moderators: GRNSHRK, ron, bfons

Post Reply
SoCalE24
Posts: 117
Joined: Sun Jan 18, 2009 8:00 pm

Wanted: Coolant temperature sending unit connector

Post by SoCalE24 »

Need the connector for the coolant temperature sending unit for an 87 M6. The sending unit is located on the coolant pipe. The one I have has melted slightly and has a intermittant short. Thanks.

SoCalE24
Chris Wright

Re: Wanted: Coolant temperature sending unit connector

Post by Chris Wright »

SoCalE24 wrote:Need the connector for the coolant temperature sending unit for an 87 M6. The sending unit is located on the coolant pipe. The one I have has melted slightly and has a intermittant short. Thanks.

SoCalE24
Are you talking about the Coolant Temp Sensor (CTS) for the ECU, not the sender for the temp gauge in the cluster, right? The one that uses the same 2 prong plug with the wire locking bail as the fuel injectors?

There is a repair kit from AutoHaus ($8.24) that comes with the plastic shell, two connectors for the wires and the rubber boot. It is a bit fiddly installing the wire ends and they can be damaged inserting them into shell if you are not careful, but it appears to be OEM.

Image


If you are in a hurry, there is also a choice of 2, pre-made, "pigtail" plugs from AutoZone:

1) One is a duplicate of the fuel injector plugs that use the wire locking bail that requires that you use a screw driver to pry the sides out to release it (no "press to release" feature). It also has the correctly shaped end to accept the rubber boot (no photo).

2) The other one has the wire locking bail that you press in to release (See below), but the downside is that the top end has straight sides so it is not shaped to accept the rubber boot, but it does look like some attempt has been made to seal around the wires. (GP Sorensen 800-9213, $10)

Both of these were actually listed under an '87 635 - fuel injection - "Pigtail" at AutoZone.
Attachments
CTS Pigtail Plug2.jpg
CTS Pigtail Plug2.jpg (27.6 KiB) Viewed 2805 times
CTS Pigtail Plug1.jpg
CTS Pigtail Plug1.jpg (20.57 KiB) Viewed 2805 times
Post Reply